Product ID:M/M CHILL CLEAN AEROSOL, 5235
MSDS Date:12/13/1995
FSC:7930
NIIN:00N077900
MSDS Number: CFLSW

MADISON BIONICS DIV SYSTEMS GENERAL

IRVING, TX 75015
US

Emergency Phone: 214-438-1381

Info Phone: 214-438-1381

Preparer: M PERKINS

Cage: DAVEN

MADISON BIONICS DIV SYSTEMS GENERAL

UNKNOW IRVING, TX 75015

Telephone: 214-438-1381

Cage: MADXS

POLYOXYPROPYLENE GLYCOL; (POLY (OXYETHYLENE/OXYPROPYLENE)

CAS: 9003-11-6

RTECS: MD0911050

OSHA PEL N/K

ACGIH TLV: N/K

ETHANOL,2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)

CAS: 102-71-6

RTECS: KL9275000

OSHA PEL N/K

ACGIH TLV: 5 MG/M3 (MFR)

BUTANE; (N-BUTANE)

CAS: 106-97-8

RTECS: EJ4200000

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM; 9495

CADMIUM (SARA 313) (CERCLA)

CAS: 7440-43-9

RTECS: EU9800000

Fraction By Weight: <0.1%

OSHA PEL 0.2 MG/M3 DUST; Z-2

ACGIH TLV: 0.01 MG/M3 DUST;9495

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

LEAD (SARA 313) (CERCLA)

CAS: 7439-92-1

RTECS: OF7525000

Fraction By Weight: <0.15%

OSHA PEL SEE 1910.1025

ACGIH TLV: 0.15MG/M3 DUST; 9495

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

NICKEL (SARA 313) (CERCLA)

CAS: 7440-02-0

RTECS: QR5950000

Fraction By Weight: <0.1%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 9495

NITRILOTRIACETIC ACID (SARA 313)

CAS: 139-13-9

RTECS: AJ0175000

Fraction By Weight: <0.1%

OSHA PEL N/K

ACGIH TLV: N/K

CONSULTATION FROM APPROP HLTH PROFESSIONALS

RTECS: 9999999ZZ

SEEK MED ATTN IF IRRIT PERSISTS. WASH CLTHG

RTECS: 9999999ZZ

GLASSES OF WATER, BUT DO NOT INDUCE VOMITING. IF

RTECS: 9999999ZZ

MEDICAL ATTENTION IF DISCOMFORT OCCURS. NOTES TO

RTECS: 9999999ZZ

LD50 LC50 Mixture:LD50 (ORAL, RAT):2300 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE CONTACT:CAUSES SEVERE IRRIT
SEEN AS TEARING & REDNESS. SWELLING OF THE CONJUNCTIVA MAY OCCUR.
COMPRESSED LIQ MAY CAUSE FROSTBITE & BURNS. SKIN CONTACT:CAUSES
SEVERE IRRIT SEEN AS ITCHING & REDNESS. PRLNG/RPTD CONTACT MAY
RSLT INSKIN SENSIT IN SOME INDIVIDUALS. COMPRESSED LIQ MAY RSLT IN
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:FROSTBITE & BURNS. INHAL:MIST CAUSES
IRRIT OF NOSE, THROAT & LUNGS SEEN AS COUGHING & CHEST PAIN.
INGEST:CAUSES GI IRRIT W/POSS NAUS, VOMIT & DIARR. MAY CAUSE DIZZ,
DROW, FAINTNESS, COLLAPSE & POSS COMA. CHRONIC:RPTD OVEREXP TO
THIS MATL MAY CAUSE DMG TO KIDNEYS, & LIVER. TARGET ORGANS:LIVER &
KIDNEYS.(SUPDAT)
Medical Cond Aggravated by Exposure:THIS PRODUCT MAY AGGRAVATE
PRE-EXISTING LIVER, KIDNEY, RESPIRATORY AND SKIN CONDITIONS.

First Aid:INHAL:REMOVE FROM AREA TO FRESH AIR. SEEK MED ATTN IF RESP
IRRIT DEVELOPS/IF BRTHG BECOMES DFCLT. EYE:IMMED RINSE EYES W/H*2O.
REMOVE ANY CNTCT LENSES & CONTINUE FLUSHING FOR AT LEAST 15 MIN.
HOLD EYE LIDS APART TO ENSURE RINSING OF ENTIRE SURF OF EYES & LIDS
W/H*20. GET IMMED MED ATTN. SKIN CONTACT:WASH AFFECTED AREAS W/LRG
AMTS OF SOAP & H*2O FOR 15 MIN. REMOVE CONTAMD CLTHG & SHOES. (ING
9)

Flash Point Method:SCC
Flash Point:>210F,>99C
Extinguishing Media:ALCOHOL FOAM, FOAM, CO*2, DRY CHEMICAL, WATER
SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . EXTINGUISHING MEDIA SHOULD BE CHOSEN BASED ON THE
NATURE OF THE SURROUNDING FIRE.
Unusual Fire/Explosion Hazard:FLAME EXTENSION IS 0 INCHES, BURNBACK IS
0 INCHES. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS TO
PREVENT BURSTING.

Spill Release Procedures:DUE TO THE NATURE OF THE AEROSOL PACKAGING, A
LARGE SPILL IS UNLIKELY. FOR A SMALL SPILL, ABSORB WITH AN INERT
MATERIAL AND TRANSFER ALL MATERIAL INO A PROPERLY LABELED CONTAINER
FOR DISPOSAL. WEAR AP PROPRIATE PROTECTIVE CLOTHING.
Neutralizing Agent:NONE KNOWN.

Handling and Storage Precautions:STORAGE TEMPERATURE MAX: 120F; MIN:
32F. STORE INDOORS. ALWAYS STORE MATERIAL IN ITS ORIGINAL
CONTAINER. KEEP CONTAINER TIGHTLY CLSD WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL
BEFORE USING THE PRODUCT. FOLLOW LABEL DIRECTIONS.

Respiratory Protection:A NIOSH APPROVED RESPIRATOR IN POORLY VENTILATED
AREAS AND/OR FOR EXPOSURE ABOVE THE ACGIH TLV OR OSHA PEL OR WHERE
MISTING EXISTS.
Ventilation:GENERAL VENTILATION IS NORMALLY ADEQUATE.
Protective Gloves:NEOPRENE RUBBER OR NITRILE GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR GENERAL DUTY WORK CLOTHING AND SHOES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:WARNING:THIS PRODUCT CONTAINS FOLLOWING CHEMICAL(S)
KNOWN TO THE STATE OF CA TO CAUSE (1) CANCER/(2) BIRTH
DEFECTS/OTHER REPRO HARM:ARSENIC (1), CADMIUM (1), LEAD (2), NICKEL
(1) & NIT RILOTRIACETIC ACID (1) AS TRACE CONTAMS. LEAD APPEARS ON
THE NAVY LISTING OF OCCUP CHEM REPRO HAZ. SEEK (ING 8)

Boiling Pt:B.P. Text:210F,99C
Vapor Pres:17.5
Vapor Density:0.6
Spec Gravity:1.0 (H*2O = 1)
pH:11.6
Evaporation Rate & Reference:2.1 (BU A/C =1)
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT WATER-WHITE; SURFACTANT ODOR.
Percent Volatiles by Volume:96

Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:AVOID HEAT, HOT SURFACES, SPARKS AND OPEN
FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.